Kawasaki VN1500 (1994) manual

Kawasaki VN1500 (1994)
7.6 · 2
PDF manual
 · 270 páginas
Inglés
manualKawasaki VN1500 (1994)

GENERAL

INFORMATION 1-3

forms the
press
fit with the base component to avoid damaging the bearings.
This
prevents
severe stress
on
the balls or needles and races, and
prevent
races and balls or needles
from
being dented. Press a ball
bearing until
it stops at the stops
in
the hole or on the shaft.
(13)
Oil Seal
and Grease Seal
Replace
any
oil
or
grease
seals that were
removed
with
new
ones, as
removal
generally
damages
seals.
When
pressing
in a seal which has manufacture/s marks,
press
it
in
with
the
marks facing out.
Seals
should be
pressed
into
place
using
a suitable drivet which contacts evenly
with
the side of seal, until the
{ace of the seal
is
even
with the end of the hole.
Before
a shaft
passes
through a seal, apply a
little high
temperature
grease
on the lips to reduce rubber to
metal
friction.
(14)
Circlip.
Retaining Ring. and Cotter Pin
Replace any circlips, retaining rings. and cotter
pins
that
were removed with new ones,
as
removal
weakens
and
deforms them. When installing circlips and retaining
rings,
take care
to compress or expand
them only enough to
install them
and
no more.
(15)
Lubrication
Engine
wear
is
generally
at
its maximum while
the engine
is warming up
and
before all the
rubbing
surfaces have an adequate
lubricative film. During assembly, oil or
grease (whichever
is more
suitable)
should be applied to any
rubbing surface which has lost its lubricative film.
Old
grease
and dirty oil should
be cleaned off. Deterioiated
grease
has lost is lubricative
quality
and may contain abrasive
foreign
panicles.
Don't
use
iust
any oil or
grease.
Some oils and
greases
in
particular
should
be
used
only in certain
applications
and may be harmful if used in an application for which they are
not intended. This manual
makes reference to
molybdenum
disulfide
grease (MoS"
)
in the assembly ol certain engine and
chassis
parts.
Always check
manufacturer recommendations
betore
using such special lubricants.
(16)
Electrical
Wires
All the electrical wires are either single-color or two-color and,
with
only a
few exceptions, must be
connected to wires of the same color. On any of the two-color
wires there is a
greater
amount of one
color
and
a lesser amount of a second color, so a two-color wire is identified by
first the
primary
color and then
the secondary color.
For
example, a
yellow
wire with
thin
red stripes is refened to as a
"yellow/red"
wire;
it
woufd
be
a
"redlvellow"
wire il the colors were reversed to make red the main color.

Wire

(cross-section)

Name of Wire Color

Red

'

Wire Strands

Yellow
Red
Yellow/Red
(17)
Replacement Parts
When there is a replacement instruction, replace these
parts
with
new
ones every time they
are removed.
These replacement
parts
will
be damaged
or lose their
original
function once removed.
(18)
Inspection
When
parts
have
been disassembled,
visually inspect
these
parts
for the following conditions or-other
damage. lf there is any doubt as to
the
condition
of them, replace them with new ones.
Abrasion
Bent
Color
change
(19)
Specifications
Crack
Dent
Deterioration

Hardening Warp

Scratch

Wear

Seizure

SDecification terms are defined as
follows:
"Standards":
show dimensions or
performances
which
brand-new
parts
or systems
have.
"Service
Limits": indicate the usable
limits. lf
the
measurement
shows excessive
wear
or deteriorated
performance,
replace the damaged
parts.

Manual

Ver el manual de Kawasaki VN1500 (1994) aquí, gratis. Este manual pertenece a la categoría Motocicletas y ha sido calificado por 2 personas con un promedio de 7.6 . Este manual está disponible en los siguientes idiomas: Inglés . ¿Tienes alguna pregunta sobre Kawasaki VN1500 (1994) o necesitas ayuda? Haz tu pregunta aquí

¿Necesitas ayuda?

¿Tiene alguna consulta sobre el Kawasaki y la respuesta no está en el manual? Haga su consulta aquí. Proporcione una descripción clara y completa de su problema y su consulta. Cuanto mejor describa su problema y consulta, más fácil será para otros propietarios de Samsung Galaxy A7 proporcionarle una buena respuesta.

Número de preguntas: 0

Kawasaki VN1500 (1994) especificaciones

A continuación encontrará las especificaciones del producto y las especificaciones del manual del Kawasaki VN1500 (1994).

General
Marca Kawasaki
Modelo VN1500 (1994)
Producto Motocicleta
Idioma Inglés
Tipo de archivo PDF

Preguntas frecuentes

¿No puede encontrar la respuesta a su consulta en el manual? Puede encontrar la respuesta a su consulta en las preguntas frecuentes sobre el Kawasaki VN1500 (1994) más abajo.

¿No aparece tu pregunta? Haz tu pregunta aquí

No hay resultados